Soils offer new hope as carbon sink
From the June 2007 edition of Agriculture Today.
The huge potential of agricultural soils to reduce greenhouse gases and increase production at the same time has been reinforced by new research findings at NSW Department of Primary Industries’ (DPI) Wollongbar Agricultural Institute.
Trials of agrichar - a product hailed as a saviour of Australia’s carbon-depleted soils and the environment - have doubled and, in one case, tripled crop growth when applied at the rate of 10 tonnes per hectare.
Agrichar is a black carbon byproduct of a process called pyrolysis, which involves heating green waste or other biomass without oxygen to generate renewable energy.
Tim Flannery, Australian of the Year and renowned scientist, conservationist, writer and explorer, is a major advocate of agrichar and pyrolysis.
In The Bulletin magazine, Flannery recently ranked “fostering pyrolysis-based technologies” fourth among his five steps for saving the planet, because they convert crop waste into fuel and agrichar which can be used to enhance soil fertility and store carbon long-term.
NSW DPI senior research scientist Dr Lukas Van Zwieten said soils naturally turn over about 10 times more greenhouse gas on a global scale than the burning of fossil fuels.
“So it is not surprising there is so much interest in a technology to create clean energy that also locks up carbon in the soil for the long term and lifts agricultural production,” he said.
The trials at Wollongbar have focused on the benefits of agrichar to agricultural productivity.
“When applied at 10t/ha, the biomass of wheat was tripled and of soybeans was more than doubled,” said Dr Van Zwieten.
“This percentage increase remained the same when applications of nitrogen fertiliser were added to both the agrichar and the control plots.
“For the wheat, agrichar alone was about as beneficial for yields as using nitrogen fertiliser only.
“And that is without considering the other benefits of agrichar.”
Regarding soil chemistry, Dr Van Zwieten said agrichar raised soil pH at about one-third the rate of lime, lifted calcium levels and reduced aluminium toxicity on the red ferrosol soils of the trial.
“Soil biology improved, the need for added fertiliser reduced and water holding capacity was raised,” he said.
The trials also measured gases given off from the soils and found significantly lower emissions of carbon dioxide and nitrous oxide (a greenhouse gas more than 300 times as potent as carbon dioxide).
NSW DPI environmental scientist Steve Kimber said an added benefit for both the farmer who applies agrichar and the environment is that the carbon in agrichar remains locked up in the soil for many years longer than, for example, carbon applied as compost, mulch or crop residue.
“We broadly categorise carbon in the soil as being labile (liable to change quickly) or stable – depending on how quickly they break down and convert into carbon dioxide,” he said.
“Labile carbon like crop residue, mulch and compost is likely to last two or three years, while stable carbon like agrichar will last up to hundreds of years.
“This is significant for farmer costs because one application of agrichar may be the equivalent of compost applications of the same weight every year for decades.
“For the environment, it means soil carbon emissions can be reduced because rapidly decomposing carbon forms are being replaced by stable ones in the form of agrichar.”
Unfortunately, agrichar is not widely available. BEST Energies Australia, a company involved with NSW DPI in the trials, has a pilot plant at Gosford which is producing minimal amounts for research purposes.
“We are hoping the technology will take hold and pyrolysis plants will be built where there is a steady stream of green or other biomass waste providing clean energy that is carbon negative,” Dr Van Zwieten said.
“But until pyrolysis plants are up and running, the availability of agrichar for farmers will be scarce.”
Visit www.bestenergies.com or contact Dr Lukas Van Zwieten or Steve Kimber, Wollongbar, (02) 6626 1200.
- Phil Bevan
Agrichar mimics Amazon
The pyrolysis process which BEST Energies Australia is using seeks to emulate creation of the highly fertile Amazonian dark earths known as ‘terra preta’.
Organic matter or biomass, including green or feedlot wastes, is converted to char during pyrolysis, a thermochemical process conducted in the absence of oxygen.
Between 25 and 70 per cent of the dry feed material is converted during pyrolysis into a high-carbon char material which is far more stable than the original biomass.
In the Amazon today, these highly fertile soils are prized.
Created by pre-Columbian populations thousands of years ago through the addition of charred organic matter, terra preta continues to be staggeringly productive despite being intensively cultivated.
BEST Energies Australia first began working on the pyrolysis process 10 years ago and now has a fully operational demonstration plant on the NSW Central Coast with the capacity to take 300 kilograms of biomass per hour.
NSW Department of Primary Industries (DPI) formed a research partnership with BEST to investigate the potential of agrichar products as soil amendments which could boost profitability while also sequestering carbon and reducing greenhouse emissions.
Initial laboratory trials conducted by DPI found that by matching soil type to char from certain feedstocks and processing conditions, yields of some crops more than doubled.
NSW has a vast untapped biomass resource from a variety of waste streams, estimated to be about seven megatonnes of biomass a year.